Waste gas of waste liquid of _ of burner of waste gas of waste liquid of boiler burner _ mixes burne

Current, to enterprise of a few large chemical industry, because its produce the complexity of the process and diversity, a variety of waste liquid and waste gas produce in bringing about manufacturing process, be like: Waste gas of annulus oxygen propane and waste liquid, annulus oxygen propane, waste gas or steam of propane dehydrogenation plant, torch reclaims gas, get together ether plant waste gas or steam, propane dehydrogenation device. Deliver the waste liquid waste gas with quantity of heat and different position, these waste liquid existence are contaminant toxic even substance, cannot discharge directly, boiler of wasteful the sources of energy must be used at burning, fortune of trash translate into, for chemical industry production produces steam, at the same time as a result of standard of Chinese environmental protection rise, the azotic oxygen compound that this boiler combustion produces discharges chroma to ask not prep above 100 Mg / Nm3, existingBoiler burnerCannot satisfy afore-mentioned requirements.

To solve afore-mentioned problems, research and development of energy-saving equipment limited company gives Yue Yang far east a kindBurner of waste liquid waste gas, can be in what waste gas comes true below the condition with liquid and aeriform the most sufficient combustion to take off saltpetre, NOXDischarge chroma to be reduced greatly.

Its principle is the boiler device of fuel of waste gas of a kind of many waste liquid and unifinication of the combustion that take off saltpetre, it includesBurnerThe chamber of a stove or furnace, burner the chamber of a stove or furnace is ordinal flue of join be issued to lower levels, take off saltpetre to absorb flue and waste gas. Pass the erect other burner hearth to haveWaste liquid waste gas mixes burner, undertake in mixture furnace of waste liquid waste gas synchronism burns enraging fluid, flue is down in what burner hearth and place narrate between, installed superheater, those who installed higher level is energy-saving implement in the flue of be issued to lower levels that narrates in place, in taking off saltpetre to absorb flue, installed device of mist of ammoniac gas blowout, waste gas passageway from on reach next parting to contain SCR reactor, inferior economizer, air intake air heater and waste gas are exported, there are two activators in SCR reactor traditional Chinese clothes.

Mix burner through waste liquid waste gas, undertake synchronism burns enraging fluid, make a variety of fluid, fuel that enrage two kinds of forms all burn adequately, take off what saltpetre absorbs flue and SCR reactor to decorate, through activator reductive flue enrages medium azotic oxide (NOX) , produce hurtless nitrogen and water, because of this NOXDischarge chroma to reduce 100 Mg / Nm3 the following, reduced NO greatlyXDischarge chroma; Burner mixes of waste gas of 4 waste liquid by fireplace of the chamber of a stove or furnace and, through installing 4 activator piece, actor choosing undertakes saltpetre reductive reaction.

Our company major is producedBurner of waste gas waste liquid, Low nitrogen burner, Fuel burner, win multinomial country patent, greeting incoming telegram seeks advice!